A silver zinc battery is a

secondary cell A rechargeable battery, storage battery, or secondary cell (formally a type of Accumulator (energy), energy accumulator), is a type of electrical battery which can be charged, discharged into a load, and recharged many times, as opposed to a ...

that utilizes

silver(I,III) oxide Silver(I,III) oxide or tetrasilver tetroxide is the inorganic compound with the formula Ag4O4. It is a component of silver zinc batteries. It can be prepared by the slow addition of a silver(I) salt to a persulfate solution e.g. AgNO3 to a Na2 ...

and

zinc Zinc is a chemical element; it has symbol Zn and atomic number 30. It is a slightly brittle metal at room temperature and has a shiny-greyish appearance when oxidation is removed. It is the first element in group 12 (IIB) of the periodic tabl ...

Overview

Silver zinc cells share most of the characteristics of the

silver-oxide battery A silver oxide battery (IEC code: S) is a primary cell using silver oxide as the cathode material and zinc for the anode. These cells maintain a nearly constant nominal voltage during discharge until fully depleted. They are available in sm ...

, and in addition, is able to deliver one of the highest specific energies of all presently known electrochemical power sources. Long used in specialized applications, it is now being developed for more mainstream markets, for example, batteries in

laptops A laptop computer or notebook computer, also known as a laptop or notebook, is a small, portable personal computer (PC). Laptops typically have a clamshell form factor with a flat-panel screen on the inside of the upper lid and an alpha ...

and hearing aids. Silver–zinc batteries, in particular, are being developed to power flexible electronic applications, where the reactants are integrated directly into flexible substrates, such as polymers or paper, using printing or chemical deposition methods. Experimental new silver–zinc technology (different to silver-oxide) may provide up to 40% more run time than

lithium-ion batteries A lithium-ion or Li-ion battery is a type of rechargeable battery that uses the reversible intercalation of Li+ ions into electronically conducting solids to store energy. Li-ion batteries are characterized by higher specific energy, energy ...

and also features a water-based chemistry that is free from the

thermal runaway Thermal runaway describes a process that is accelerated by increased temperature, in turn releasing Thermal energy, energy that further increases temperature. Thermal runaway occurs in situations where an increase in temperature changes the cond ...

and flammability problems that have plagued the lithium-ion alternatives.

Chemistry

The silver–zinc battery is manufactured in a fully discharged condition and has the opposite electrode composition, the

cathode A cathode is the electrode from which a conventional current leaves a polarized electrical device such as a lead-acid battery. This definition can be recalled by using the mnemonic ''CCD'' for ''Cathode Current Departs''. Conventional curren ...

being of metallic silver, while the

anode An anode usually is an electrode of a polarized electrical device through which conventional current enters the device. This contrasts with a cathode, which is usually an electrode of the device through which conventional current leaves the devic ...

is a mixture of

zinc oxide Zinc oxide is an inorganic compound with the Chemical formula, formula . It is a white powder which is insoluble in water. ZnO is used as an additive in numerous materials and products including cosmetics, Zinc metabolism, food supplements, rubbe ...

and pure

powders. The electrolyte used is a

potassium hydroxide Potassium hydroxide is an inorganic compound with the formula K OH, and is commonly called caustic potash. Along with sodium hydroxide (NaOH), KOH is a prototypical strong base. It has many industrial and niche applications, most of which utili ...

solution in water. During the charging process, silver is first oxidized to

silver(I) oxide Silver oxide is the chemical compound with the formula Ag2 O. It is a fine black or dark brown powder that is used to prepare other silver compounds. Preparation Silver oxide can be prepared by combining aqueous solutions of silver nitrate and ...

: 2 Ag(s) + 2 OH⁻ → Ag₂O + H₂O + 2 e⁻ and then to silver(II) oxide : Ag₂O + 2 OH⁻ → 2 AgO + H₂O + 2 e⁻, while the zinc oxide is reduced to metallic zinc : 2 Zn(OH)₂ + 4 e⁻ 2 Zn + 4 OH⁻. The process is continued until the cell potential reaches a level where the decomposition of the electrolyte is possible at about 1.55 volts. This is taken as the end of a charge, as no further charge is stored, and any

oxygen Oxygen is a chemical element; it has chemical symbol, symbol O and atomic number 8. It is a member of the chalcogen group (periodic table), group in the periodic table, a highly reactivity (chemistry), reactive nonmetal (chemistry), non ...

that might be generated poses a mechanical and fire hazard to the cell.

History and usage

This technology had the highest

energy density In physics, energy density is the quotient between the amount of energy stored in a given system or contained in a given region of space and the volume of the system or region considered. Often only the ''useful'' or extractable energy is measure ...

prior to lithium technologies. Primarily developed for aircraft, they have long been used in space launchers and crewed spacecraft, where their short cycle life is not a drawback. Non-rechargeable silver–zinc batteries powered the first Soviet

Sputnik Sputnik 1 (, , ''Satellite 1''), sometimes referred to as simply Sputnik, was the first artificial Earth satellite. It was launched into an elliptical low Earth orbit by the Soviet Union on 4 October 1957 as part of the Soviet space progra ...

satellites, as well as US

Saturn Saturn is the sixth planet from the Sun and the second largest in the Solar System, after Jupiter. It is a gas giant, with an average radius of about 9 times that of Earth. It has an eighth the average density of Earth, but is over 95 tim ...

launch vehicles, the

Apollo Lunar Module The Apollo Lunar Module (LM ), originally designated the Lunar Excursion Module (LEM), was the lunar lander spacecraft that was flown between lunar orbit and the Moon's surface during the United States' Apollo program. It was the first crewed sp ...

lunar rover A lunar rover or Moon rover is a space exploration Rover (space exploration), vehicle designed to move across the surface of the Moon. The Apollo program's Lunar Roving Vehicle was driven on the Moon by members of three American crews, Apollo 15, ...

and life-support backpack. The primary power sources for the Apollo command module (CM) were the hydrogen/oxygen

fuel cells A fuel cell is an electrochemical cell that converts the chemical energy of a fuel (often hydrogen) and an oxidizing agent (often oxygen) into electricity through a pair of redox reactions. Fuel cells are different from most batteries in req ...

in the service module (SM). They provided greater energy densities than any conventional battery, but peak-power limitations required supplementation by silver–zinc batteries in the CM that also became its sole power supply during re-entry after separation of the service module. Only these batteries were recharged in flight. After the

Apollo 13 Apollo 13 (April 1117, 1970) was the seventh crewed mission in the Apollo program, Apollo space program and would have been the third Moon landing. The craft was launched from Kennedy Space Center on April 11, 1970, but the landing was abort ...

near-disaster, an auxiliary silver–zinc battery was added to the service module as a backup to the fuel cells. The Apollo service modules used as crew ferries to the

Skylab Skylab was the United States' first space station, launched by NASA, occupied for about 24 weeks between May 1973 and February 1974. It was operated by three trios of astronaut crews: Skylab 2, Skylab 3, and Skylab 4. Skylab was constructe ...

space station were powered by three silver–zinc batteries between undocking and service module jettison, as the hydrogen and oxygen tanks could not store fuel-cell reactants through the long stays at the station. These cells are found in applications for the military, for example in

Mark 37 torpedo The Mark 37 torpedo is a torpedo with electrical propulsion, developed for the US Navy after World War II. It entered service with the US Navy in the early 1950s, with over 3,300 produced. It was phased out of service with the US Navy during the ...

es and on

Alfa-class submarine The Alfa class, Soviet designation Project 705 Lira (, meaning "Lyre", NATO reporting name Alfa), was a class of nuclear-powered attack submarines in service with the Soviet Navy from 1971 into the early 1990s, with one serving in the Russian Na ...

s. in the 1960s

General Motors General Motors Company (GM) is an American Multinational corporation, multinational Automotive industry, automotive manufacturing company headquartered in Detroit, Michigan, United States. The company is most known for owning and manufacturing f ...

developed an electric car called Electrovair, which was powered by a zinc-silver battery produced by Eagle-Picher. However, the battery was expensive and lasted only a hundred charge-discharge cycles.

References

{{Galvanic cells Disposable batteries Metal oxide–zinc batteries

Overview

Chemistry

History and usage

See also

References