MV Golden Ray

The MV ''Golden Ray'' was a roll-on/roll-off cargo ship designed to carry automobiles that capsized on 8 September 2019 in St. Simons Sound near the Port of Brunswick in Georgia, United States. She was eventually declared a total loss and was removed as scrap.

Design

''Golden Ray'' was built by Hyundai Mipo Dockyard in Ulsan, South Korea. Her keel was laid on 23 December 2015, and she was launched on 26 August 2016. She was delivered from the builder on 12 May 2017, and at the time of her capsizing was owned and operated by Hyundai Glovis. ''Golden Ray'' measured 71,118 gross tons and 20,995 deadweight tons, and was long, with a beam of . She was powered by a single diesel engine that gave her a service speed of via a single propeller, and had a capacity of up to 7,400 cars.

Capsizing

''Golden Ray'' began its final voyage by loading vehicles at the ports of Veracruz (19–22 Aug 2019), Altamira (24–25 Aug), and Freeport (27–30 Aug); from there, the ship proceeded to Jacksonville (6–7 Sep) and Brunswick (7–8 Sep), where some vehicles were unloaded and others were loaded. It then was scheduled to sail to Baltimore, Wilmington, Beirut, Jeddah, Sohar, Jebel Ali, Dammam, and Kuwait. When it left Brunswick, the vessel was carrying approximately 4,300 brand new Kia and Hyundai cars manufactured in Mexico, and vehicles made by other companies including Chevrolet, GMC, GM, Mercedes-Benz, and Ram to Baltimore, Maryland; some were destined for delivery to the Middle East.

On 8 September 2019 at approximately 0137  EDT, the ''Golden Ray'' capsized within the Port of Brunswick's harbor, shortly after unberthing and proceeding towards the Port of Baltimore. After the cargo was loaded at the dock in Brunswick, the chief officer transferred of water from the no. 5 port water ballast tank in the ship's double bottom to the no. 5 starboard water ballast tank, correcting the list from 0.42° to port to 0.03° to starboard. At the time, ''Golden Ray'' was displacing , with drafts of forward and aft, respectively. The ship departed the dock at approximately 0054 EDT and executed two turns to port at 0122 EDT and 0129 EDT, traveling at approximately . At 0135 EDT, the state-provided maritime pilot ordered a starboard turn; the pilot noted the vessel "felt directionally unstable ... when I started the turn, she wanted to keep turning" and ordered the rudder be returned to center at 0137 EDT. However, the vessel started to heel to port rapidly. To counteract this, the rudder was turned to port, but the vessel continued to turn to starboard and heel over. The list reached 60° within a minute as the bow thruster and reverse engine orders were issued to counteract the list. At 0140 EDT, the ship ran aground. The ship's master previously had ordered the portside pilot door on deck 5 to be opened at 0108 EDT, to prepare for the departure of the pilot. Water began to enter the vessel through the open pilot door, flooding the engine and steering gear rooms; as tugboats pushed the ship out of the deep channel, it came to rest on its port side.

This serious listing caused the port to close immediately. Two United States Coast Guard (USCG) response boats were launched from Coast Guard Station Brunswick, ''CG 45741'' and ''CG 29139'', arriving at 0205 and 0300 EDT, respectively. All 23 crewmen on board as well as an American pilot survived, including three engineers who were in the ship's engine room at the time of the incident. The pilot and 19 of the 23 crew were rescued by first responders the first night; the last rescued that night was the chief engineer at 0645 EDT, who was in a stateroom beneath the port bridge wing. At approximately 0430 EDT, first responders noticed smoke and flames erupting from the starboard side, as a fire was consuming the vehicles inside the ship; the toxic smoke and heat prevented further rescue operations for approximately 24 hours until the fire had burned itself out.

The next day, the USCG located and rescued the remaining four crew members that were missing, three engineers and an engineering cadet. At the time the ship capsized they were trapped in the stern: two engineers were in the engine control room on deck 4, while the other engineer and cadet were in the adjacent engine room occupying decks 2 and 3 making routine checks. The engineers in the control room were prevented from leaving by incoming water, which was spilling down the primary access stairwell from the open door on deck 5; one was able to escape through an aft-facing door and joined the engineer and cadet in the engine room, while the other stayed in the control room. On the same day of the capsize, at 1612 EDT, first responders reported hearing tapping noises from within the vessel. A hole was drilled at 1300 EDT on September 9 to contact the engineers, who were trapped in sweltering heat; the hull was cut open and all four were rescued by 1751 EDT, appearing to be in good medical condition.

Investigations

The incident was suspected to be related to a sudden loss of stability, possibly due to cargo stowage and incorrect water ballasting. A Hyundai Glovis executive told the news media that "there was some kind of an internal fire that could not be controlled and then it capsized". A fire delayed the rescue of the last crew member.

In September 2020, the USCG held a public hearing to gather factual evidence and testimony for the Marine Board of Investigation into the capsizing of the M/V ''Golden Ray'', chaired by Captain Blake Welborn. The public hearing concluded on September 22.

The National Transportation Safety Board agreed to assist in investigating the capsize, with two investigators assigned to the case. A final NTSB report, adopted 26 August 2021, determined the cause of sinking to be a combination of factors. The direct cause was incorrect entries for ballast for the ship's stability calculation program. The program entry error was compounded because there was no procedure to verify the entries. The incorrect entries meant the program did not compute the proper levels for ballast tanks, which left the ship unstable as she made a sharp turn when exiting the channel. When the ship heeled to port, the open portside pilot door allowed water to enter; other watertight doors that were not properly closed also allowed flooding.

Environmental concerns

In November 2019, ''The New York Times'' quoted Fletcher Sams, the executive director of the Altamaha Riverkeeper, a nonprofit that monitors pollution in Georgia's Altamaha River, describing “a concoction of contaminants” already found in the water that included gas and heavy bunker fuel that powered the ship, as well as gasoline, diesel and antifreeze from the vehicles that were being transported. As of mid-November 2019, it remained unknown how much had flowed into the sound. The discharge could have been limited to a small amount, but the oil and chemicals could have also washed into marshland and seeped into the sediment. Concern was also expressed about a new wave of contaminants from the capsized ship when she was cut up for salvage. Oil-coated grass and floating tarballs were observed around St. Simon's Sound and St. Simon's Island. On 1 August 2021, upon completion of the section six cut of the ship, a significant amount of oil began to leak. As a result, beach advisories were issued across the St Simon’s Sound and Jekyll Island area. Mitigation strategies were put in place in and around the environmental protection barrier to prevent further spreading of the oil. The barrier was originally put in place to protect marine life from the dismantling effort.

Salvage

The ship had 24 fuel tanks, and all were almost full when she capsized. By 27 September, two of them had been pumped out and vents on the others were plugged. 15,500 US gallons (59,000 L; 12,900 imp gal) had been pumped out, of a total of 300,000 US gallons (1,100,000 L; 250,000 imp gal) believed to be on board. The port continued to operate through the salvage process, with some delays. The salvage operation was expected to take several months, and a team was sent to Chile to examine her sister ship, ''Silver Ray'', to better understand the internal layout. There are twelve tanks near the engine room and twelve elsewhere on the ship. The salvage crews are monitoring for any pollution caused by leaks.

In October 2019, due to the fire, saltwater corrosion, and salvage costs, the ''Golden Ray'' was declared a total loss, and it was announced that the ship would be cut up in place and scrapped. Insurance losses on the ship are estimated at $70-80 million, and $80 million in her contents. The salvage work will be done by T&T Salvage utilizing the Versabar heavy lift vessel . On 13 December 2019, Coast Guard authorities confirmed that salvage workers had removed all the vessel's fuel.

On , salvage workers had to cope with another fire on board the vessel. In February 2020, it was announced that the vessel would be cut into eight sections weighing between 2,700 and 4,100 tons that will then be removed on barges for disposal. In late October, the ''VB-10,000'' heavy lift vessel arrived and was in position over the wreck on 27 October. Cutting operations began on 6 November 2020.

In late November 2020, the first cut was completed, removing the vessel's bow. It was expected to take 24 hours, but after delays caused by tropical storms, and a broken cutting chain, it took over 20 days. The stern was intended to be removed in the second cut.

On , preparations for the separation of "Section 7" from the wreck were underway. Preparations were also underway for the cutting of "Section 2".

On , the ship caught fire and crews were dispatched to extinguish the flames. The fire, which broke out while a section containing the engine room was being cut free, was extinguished the same day.

On , "Section 3" was removed leaving two more cuts and three more sections before the project would be complete, which was still expected to take several more months.

The final cut was completed on , and preparations were made to lift the two remaining sections and secure them to barges. The sections were held in the Port of Brunswick until they could be prepared for transport, which included removing all automobiles from the ship for processing at a local scrapyard. The ship sections themselves were then transported by barge to Gibson, Louisiana to be broken up. The final section of the wreck was removed on 25 October 2021 and the removal of the wreck was completed. The Coast Guard stated it was the largest wreck removal operation in United States history.

On 26 September 2021, the Coast Guard held a press conference, to announce the removal of the last section, and the completion of the largest removal of a capsized ship in U.S. history. This was a "a difficult and complicated operation." Experts from various nations were consulted. In addition to the ship herself, the salvage operation collected debris from the shore and water amounting to of debris not related to the ship, and of debris from the ship. This resulted in the nearby marshes, and beaches, being cleaner than they had been in many years.

See also

* MV ''Höegh Osaka'', a car carrier which nearly capsized in January 2015 under similar circumstances to the ''Golden Ray'' in the Solent, United Kingdom
* MV ''Tricolor'', a sunken car carrier which was cut into pieces during salvage starting in 2003

References

External links

*
*
*

{{DEFAULTSORT:Golden Ray
Ro-ro ships
Maritime incidents in 2019
2016 ships
Ships built by Hyundai Heavy Industries Group