Katsuobushi Block

is simmered, smoked and fermented skipjack tuna (''Katsuwonus pelamis'', sometimes referred to as bonito). It is also known as bonito flakes or broadly as .

Shaved ''katsuobushi'' and dried kelp—''kombu''—are the main ingredients of ''dashi'', a broth that forms the basis of many soups (such as miso) and sauces (such as ''soba no tsukejiru'') in Japanese cuisine.

''Katsuobushi''s distinct umami taste comes from its high inosinic acid content. Traditionally made ''katsuobushi'', known as ''karebushi'', is deliberately fermented with ''Aspergillus glaucus'' fungus in order to reduce moisture. ''Katsuobushi'' has also been shown to impart '' kokumi'' (a term translated as "heartiness").

Traditional production process

The fish is beheaded, gutted, and filleted, with the fatty belly, which does not lend well to being preserved, trimmed off. The fillets are then arranged in a basket and simmered just below boiling for an hour to an hour and a half, depending on their size.

The rib bones are then removed and the fillets smoked for up to a month using oak, pasania, or castanopsis wood. They are smoked for five to six hours in one session, left to rest one day for the condensation to rise to the surface, then fired and smoked again the next day. This smoking and resting cycle is repeated 12–15 times in total. At this point, the fish is dry and hard, and the built-up tar from the smoke and excess fat is cleaned from the surface using a grinder. At this stage the fillets are called and most commonly found in stores shaved and packaged for sale under the name or ''hanakatsuo''. They are not true ''katsuobushi'' without the last fermentation stage, but still valued as a good substitute.

The last stage of creating ''katsuobushi'' is to allow the fish to sun-dry using the assistance of mold. The fillets are sprayed with ''Aspergillus glaucus'' culture and left for two weeks in a closed cultivation room. The mold ferments the fillets and also draws out any residual moisture.

The mold is continually scraped off, with further sun-drying increasing hardness and dryness until the fillet resembles a piece of wood, with less than 20% of its original weight. By definition, only fillets that have been treated in this manner may be referred to as ''katsuobushi''. After repeating this process of mold growth and sun-drying at least twice, the ''katsuobushi'' can also be called , and fillets repeating this process more than three times can be called . When tapped together lightly, they sound almost metallic, and unlike their dull beige outer appearance, when broken open they are a translucent deep ruby color inside. Rarely, very high-end ''honkarebushi'' repeat this drying process for over two years.

In the Edo era, it was common for ''katsuobushi'' to go through an extra step, the so-called process. After the fillets are boiled and their rib bones removed the fish are put in steaming baskets stacked atop one another for one to two hours a few meters above a burning wood fire. These are rotated to assure an equal exposure to the smoke. The result is more flavorful and resistant to deterioration. Due to the extra cost and facilities required only a few factories following ''tebiyama-shiki'' remain.

Shaving

Traditionally, chunks of ''katsuobushi'' were shaved as needed with an instrument similar to a wood plane called a ''katsuobushi kezuriki''.

Today ''katsuobushi'' is typically sold in bags of small pink-brown shavings, which vary by thickness: smaller, thinner shavings, called ''hanakatsuo'' (), are used as a flavoring and topping for many Japanese dishes, such as okonomiyaki, while the larger thicker, called ''kezurikatsuo'' (), are favored for making the widely used dashi stock.

Uses

In addition to making dashi, other popular uses of ''katsuobushi'' include:
* Okaka, finely chopped ''katsuobushi'' dressed with soy sauce.
** As a stuffing for rice balls (''onigiri'').
** As a topping for rice. Popular for bentō, often covered with strips of laver.
** Dried okaka is used as an ingredient of ''furikake'' rice topping (called "okaka furikake").
* As a seasoning for cold tofu (''hiyayakko'', ) along with grated ginger and Welsh onion (a type of spring onion).
* Sprinkled with sesame seeds and chopped laver atop cold soba noodles ( zarusoba).
* As a topping on takoyaki, okonomiyaki or agedashi dōfu.
* As a seasoning on century egg along with sesame oil and soy sauce.
* As a high-protein treat for cats sold at pet stores.
* As a topping for ramen mixed with salt.

Health

The mycotoxin beta-nitropropionic acid has been found on ''katsuobushi'' as well as in miso and in soy sauce, two other Japanese fungal fermented products. Certain strains of ''A. glaucus'' are reported to produce mycotoxins.

Due to the smoking process which involves tar and charcoal, amounts of benzopyrene exceeding EU standards, as much as 37μg per kilogram, have been detected in commercially sold ''katsuobushi''. As a result, they have been banned for sale in the European Union.

See also

* List of dried foods
* Maldives fish

References

External links

Katsuobushi types and production methods
*

{{Authority control

Japanese condiments
Dried fish
Fermented fish
Smoked fish
Umami enhancers
Toppings