The Clay's Ferry Bridge is a bridge that carries

Interstate 75 Interstate 75 (I-75) is a major north–south Interstate Highway in the Great Lakes and Southeastern regions of the United States. As with most Interstates that end in 5, it is a major cross-country, north–south route, traveling from S ...

along with

US 25 U.S. Route 25 or U.S. Highway 25 (US 25) is a north–south United States Numbered Highway that runs for in the Southern United States, Southern and Midwestern United States, Midwestern U.S. Its southern terminus is in Brunswick ...

and

US 421 U.S. Route 421 (also U.S. Highway 421, US 421) is a diagonal northwest–southeast United States Numbered Highway in the states of North Carolina, Tennessee, Virginia, Kentucky, and Indiana. The highway runs for from Fort Fisher, North Car ...

across the

Kentucky River The Kentucky River is a tributary of the Ohio River in Kentucky, United States. The river and its tributaries drain much of eastern and central Kentucky, passing through the Eastern Coalfield, the Cumberland Mountains, and the Bluegrass re ...

between

Madison Madison may refer to: People * Madison (name), a given name and a surname * James Madison (1751–1836), fourth president of the United States * Madison (footballer), Brazilian footballer Places in the United States Populated places * Madi ...

and Fayette counties.

History

The first Clay's Ferry Bridge was opened in 1869. Prior to this, service across the Kentucky River was provided by ferry, which had been established since 1792. In 1906, the bridge was purchased by the newly formed Clays Ferry Bridge Company. After the State of Kentucky purchased the crossing on April 1, 1929, the bridge was made part of US 25. Despite this, the bridges tolls were not removed until December 24, 1930. On February 6, 1941, plans for a new high rise span were announced. It was estimated to cost around $935,279. Approval for the construction of the new Clay's Ferry Bridge was granted by the Secretary of War on September 12, and work on this new span began on October 1. Even though World War II-related steel rationing delayed completion of the superstructure, the piers were completed on January 7, 1943. Steel was eventually obtained. After multiple delays related to winter weather, the bridge was officially opened to traffic on August 17, 1946. It was above the river level and was the tallest bridge east of the Mississippi after completion, with a total length of . In 1951, us route 421 was routed over the high rise bridge. In 1955, the low rise bridge was given a rehabilitation. In 1963, a twin high rise bridge was completed just south of the existing bridge and traffic ran in two lanes in each direction, With the completion of this new span, the original span was made northbound only. After over two decades of use, a fatigue analysis of the Clays Ferry Bridge was completed. This was conducted in 1988 by Theodore Hopwood II, and Vishwas G. Oka, from the Kentucky Transportation Center Research, Report 539. In 1989, plans were announced to demolish the 1946 and 1963 bridge's superstructures and build a third pier. At this point, a new unified superstructure would be constructed across all three. This allowed for the addition of an extra vehicular lane plus shoulders. Construction started on January 6, 1994. On February 29, 1996, a crane leaned forward at a 30-degree angle while attempting to lift a 17-ton steel beam, nearly collapsing the bridge. Fearing the crane might fall into the river, engineers closed the bridge until 11:15 p.m. In this span of time, a new crane was brought in to carry the steel beam, in addition to stabilizing the crane. The operator chose to drop the beam onto the river bank, preventing it from falling off. This beam was the only item damaged during the incident. In the summer of 1998, crews finished painting, and by November, the entire project was completed. Each northbound/southbound roadway is wide, and total traffic over the bridge was 75,000 vehicles per day in 2015. A resurfacing of the bridge began on August 1, 2021, and was projected to be completed by October 27. It was completed ahead of schedule on October 11.

References

External links

* {{coord, 37.8838, -84.3393, type:landmark_region:US-KY, display=title Bridges completed in 1946 Bridges completed in 1963 Bridges completed in 1998 Road bridges in Kentucky Transportation in Madison County, Kentucky Transportation in Lexington, Kentucky Buildings and structures in Madison County, Kentucky Buildings and structures in Lexington, Kentucky Bridges over the Kentucky River Interstate 75 U.S. Route 25 U.S. Route 421 Bridges of the United States Numbered Highway System Bridges on the Interstate Highway System