The Anderson Powerpole is a family of electrical connectors by Anderson Power Products (APP),
/ref> although

plug compatible Plug compatible refers to " hardware that is designed to perform exactly like another vendor's product." The term PCM was originally applied to manufacturers who made replacements for IBM peripherals. Later this term was used to refer to IBM-com ...

connectors are now available from alternate sources. Specific variants of this series of connectors have become

de facto standard A ''de facto'' standard is a custom or convention that is commonly used even though its use is not required. is a Latin phrase (literally " of fact"), here meaning "in practice but not necessarily ordained by law" or "in practice or actuality, ...

s for conveying "higher power"

direct current Direct current (DC) is one-directional electric current, flow of electric charge. An electrochemical cell is a prime example of DC power. Direct current may flow through a conductor (material), conductor such as a wire, but can also flow throug ...

(DC) electrical power, although these standards are inconsistent and sometimes ignored.

Overview

Powerpole connectors are physically and electrically

hermaphroditic A hermaphrodite () is a sexually reproducing organism that produces both male and female gametes. Animal species in which individuals are either male or female are gonochoric, which is the opposite of hermaphroditic. The individuals of many ...

, thus avoiding the need to worry about which end is the plug and which the socket, or which end has the correct polarity. This is in contrast to the physically—but not electrically—hermaphroditic two-wire trailer plug. Powerpole connectors are available with

current Currents, Current or The Current may refer to: Science and technology * Current (fluid), the flow of a liquid or a gas ** Air current, a flow of air ** Ocean current, a current in the ocean *** Rip current, a kind of water current ** Current (hydr ...

ratings of up to 180

amperes The ampere ( , ; symbol: A), often shortened to amp,SI supports only the use of symbols and deprecates the use of abbreviations for units. is the unit of electric current in the International System of Units (SI). One ampere is equal to 1 c ...

. The 15/30/45 ampere-rated connectors are the most common, using the same plastic housing and differing only in the metal contact inserted into the housing. The contact is selected based on the

ampacity Ampacity is a portmanteau for ''ampere capacity'', defined by United States National Electrical Codes. Ampacity is defined as the maximum current, in amperes, that a conductor can carry continuously under the conditions of use without exceeding ...

and

wire gauge Wire gauge is a measurement of wire diameter. This determines the amount of electric current the wire can safely carry, as well as its electrical resistance and weight. Types of wire gauge Wire gauges may be broadly divided into two groups, t ...

. The colors can be used to signify signal types (power, speaker, logic, microphone audio, etc.) or differing voltages. Powerpole connectors can be attached side to side and also stacked on top of each other to make, for example, four connections with one plug insertion. The contacts are rated for 100,000 no-load insertions and 250 hot-plugs at full load. Larger Powerpole connectors (the SB/Multipole series) with two or three contacts in one molded housing are commonly used in various industrial settings, including as a battery connection for some

uninterruptible power supplies An uninterruptible power supply (UPS) or uninterruptible power source is a type of continual power system that provides automated backup electric power to a load when the input power source or mains power fails. A UPS differs from a tradition ...

(UPS), removable vehicle winches, many electric forklifts, and other

electric vehicle An electric vehicle (EV) is a motor vehicle whose propulsion is powered fully or mostly by electricity. EVs encompass a wide range of transportation modes, including road vehicle, road and rail vehicles, electric boats and Submersible, submer ...

s. They range from 50 to 500 amps, 600 volts.

Competitors

Some of Anderson's earlier patents have expired, thus other manufacturers have released plug-compatible connectors, such as "AMP Power Series" by Tyco /

TE Connectivity TE Connectivity plc is an American-Irish domiciled technology company that designs and manufactures electrical and electronic components. It serves several industries, including automotive, aerospace, defense, medical, and energy. TE Connecti ...

, Sermos, and Lightspeed.''Electric Flight Power Connectors''; Sailplane & Electric Modeler Magazine; January 1, 2000.
/ref>

Patents

The Powerpole connector was designed and patented by "Albert & J M Anderson Mfg Comp", then more recently by "Anderson Power Products".

Color coded multipole series

For the larger multipole design, which is available in up to 700 A sizes, each color is physically keyed so as to mate only with a like colored connector, and Anderson published a list of recommended voltage for each color: * Model railroad uses all of the above colors for various purposes.

De facto standards

Amateur astronomy

Many companies in the amateur astronomy space have adopted Powerpole connectors, as a large number of astronomical devices use 12-volts, and Powerpole connectors offer a low cost and easy solution to make adaptors, extensions, and distribution panels.

Amateur radio

The Powerpole connector has been adopted by many segments of the

Amateur Radio Amateur radio, also known as ham radio, is the use of the radio frequency radio spectrum, spectrum for purposes of non-commercial exchange of messages, wireless experimentation, self-training, private recreation, radiosport, contesting, and emer ...

(Ham Radio) community as their standard 12-volt

DC power connector A DC connector (or DC plug, for one common type) is an electrical connector that supplies direct current (DC) power. Compared to domestic AC power plugs and sockets, DC connectors have many more standard types that are not interchangeable. The d ...

for everything from radios to DC power sources to accessories.Amateur Radio Standard DC Connector; VARA.
/ref> Three notable groups are the Amateur Radio Emergency Service (ARES), the

Radio Amateur Civil Emergency Service The Radio Amateur Civil Emergency Service (RACES) is an emergency radio service authorized in Part 97.407 of the Federal Communications Commission (FCC) rules and regulations governing amateur radio in the United States. and the Wireless Institute Civil Emergency Network (WICEN).Wireless Institute Civil Emergency Network
/ref> Standardization allows equipment owned by different hams to be used together without needing adapters in emergencies, at public service events, at field day, during contests, when borrowing equipment, etc. The Anderson Powerpole connector is more expensive than the older de facto standards of the two-wire trailer plug and the Molex connector, but provides a more reliable electrical connection (both mechanically and electrically), and is easier to adapt to a wider range of wire gauges. Another advantage over the older trailer or Molex connectors is the Powerpole's superior ratings to withstand 100,000 no-load insertions and 250 hot-plugs at full load. The specific hermaphroditic nature of the powerpoles is a significant advantage since batteries can be both a power source or a power sink, a power supply can be connected to a radio and/or a battery, and multiple batteries, radios, and/or redundant power sources can be connected in parallel using the same power distribution panels. Connectors in which non-hermaphroditic contacts are arranged in a hermaphroditic arrangement (such as bullet connectors used in low end solar equipment) can be electrically incompatible (reverse polarity damages equipment) and non-hermaphroditic connectors can be mechanically incompatible with each other (won't mate). Many pieces of amateur radio equipment run on 12-volt DC automotive voltage, which is also called 13.8-volt DC. The voltage delivered by a

lead–acid battery The lead–acid battery is a type of rechargeable battery first invented in 1859 by French physicist Gaston Planté. It was the first type of rechargeable battery to be invented. Compared to modern rechargeable batteries, lead–acid batteries ha ...

with six-cells used as an

automotive battery An automotive battery, or car battery, is a usually 12 Volt lead-acid rechargeable battery that is used to start a motor vehicle, and to power lights, screen wiper etc. while the engine is off. Its main purpose is to provide an electric curren ...

will vary depending on various electrical loads in a vehicle. Without loads the battery will float from 11.7 to 12.8 volts, and while charging from an alternator the voltage will increase to 13.8–14.4 volts DC. For use in amateur radio, the community has adopted a standard color code, polarity, and specific physical arrangement for assembling pairs of Powerpole connectors. One red and one black powerpole housing can be physically arranged in 4 topologically different mechanical orientations (red left, red right, red top, red bottom—when viewed from contact side with tongue up), 2 of which are mechanically incompatible (connectors won't mate with ARES) and 1 is electrically incompatible (will mate but reverse polarity) with the ARES standard; there are also additional unusual configurations in which one housing is rotated 90 degrees. The standard is red positive and black negative. When viewed from the contact side, a

mnemonic A mnemonic device ( ), memory trick or memory device is any learning technique that aids information retention or retrieval in the human memory, often by associating the information with something that is easier to remember. It makes use of e ...

for remembering the arrangement is: "Red nRight — Tongue nTop" (note the first letter alliteration). West Mountain Radio, a major amateur radio supplier, has had a few 24 V DC products in their catalog for over a decade. They incorporate a 24 volt standard that has the orange body as +24 volts. An orange and black pair would be +24 volts on the orange and ground on the black.

Model railways

model railway Railway modelling (UK, Australia, New Zealand, and Ireland) or model railroading (US and Canada) is a hobby in which rail transport systems are Model building, modelled at a reduced Scale (ratio), scale. The scale models include locomotives ...

s, the NTRAK Modular Railroading Society adopted the Powerpole PP30 connector as a recommend practice in 2005. and as a standard in 2011. The use of the older Cinch-Jones connector has been

deprecated Deprecation is the discouragement of use of something human-made, such as a term, feature, design, or practice. Typically something is deprecated because it is claimed to be inferior compared to other options available. Something may be deprec ...

, but is still permitted on legacy modules. However, the owner of a module with Cinch-Jones plugs is now required to provide adapter cables to the newer standard.Wiring and Connectors Recommended Practice; NTRAK.
North Raleigh Model Railroad Club (NRMRC) also uses Anderson Powerpole connectors. The Free-mo modular standard adopted Powerpole as the new connector standard as of 1 July 2015, with a one-year transition period to convert existing Jones connectors.The Official Free-mo Standard S4.5
/ref>

Robotics

The connectors are used by some

robot A robot is a machine—especially one Computer program, programmable by a computer—capable of carrying out a complex series of actions Automation, automatically. A robot can be guided by an external control device, or the robot control, co ...

builders, including the

FIRST Robotics Competition FIRST Robotics Competition (FRC) is an international high school robotics competition operated by ''FIRST''®. Each year, teams of high school students, coaches, and mentors work to build robots capable of competing in that year's game. Robots c ...

and R2-D2 Builders Club.Robot Power Management Using Anderson Powerpole Connectors; First Tech Challenge.
Robot Wiring Guide; First Tech Challenge.

Radio control

The Powerpole connectors are used by

radio control Radio control (often abbreviated to RC) is the use of control signals transmitted by radio to remotely operate a device. Examples of simple radio control systems are garage door openers and keyless entry systems for vehicles, in which a small ha ...

(R/C) model hobbyist clubs. They may be known as "SB" connectors or "Sermos" connectors with the suppliers in that community.

Data centers

Some buildings including

data center A data center is a building, a dedicated space within a building, or a group of buildings used to house computer systems and associated components, such as telecommunications and storage systems. Since IT operations are crucial for busines ...

s are increasingly designed for 380 V DC

power distribution Electric power distribution is the final stage in the delivery of electricity. Electricity is carried from the transmission system to individual consumers. Distribution substations connect to the transmission system and lower the transmission v ...

, as a way of improving

electrical efficiency The efficiency of a system in electronics and electrical engineering is defined as useful power output divided by the total electrical power consumed (a vulgar fraction, fractional Expression (mathematics), expression), typically denoted by the G ...

. DC power distribution has resulted in the need to standardize a

Low Voltage In electrical engineering, low voltage is a relative term, the definition varying by context. Different definitions are used in electric power transmission and distribution, compared with electronics design. Electrical safety codes define "low vo ...

(LV) connector with an integral ground conductor, which is safe for use by untrained personnel. The tendency of DC connectors to spark when disconnected from an inductive load requires the connector's insulating housing to contain the plasma arc, in addition to normal requirements such as preventing accidental finger contact. Examples of such connectors are the Anderson Powerpole Pak connectors and the SDG ( Saf-D-Grid) connector, designed with the form factor of an IEC C13 connector.

References

External links

{{Commons category, Anderson Powerpole ; Official :
APP official website
:
Powerpole connector webpage
- archived ;
Powerpole catalog
- archived ; Amateur Radio connector standards :

VARA ::

California Governors Office of Emergency Services ("CAL-OES") ; Model Railroad connector standards :

NTRAK :
Electrical Standards for NTRAK Module Wiring
North Raleigh Model Railroad Club ; Robotics connector standards :
Robot Wiring Guide
First Tech Challenge :
Robot Power Management Using Anderson Powerpole Connectors
First Tech Challenge Amateur radio DC power connectors