Soviet submarine K-431

''K-431'' (originally the ''K-31'') was a Soviet nuclear-powered submarine that had a reactor accident on 10 August 1985. It was commissioned on 30 September 1965. An explosion occurred during refueling of the submarine at Chazhma Bay, Vladivostok. There were ten fatalities and 49 other people suffered radiation injuries. TIME magazine has identified the accident as one of the world's "worst nuclear disasters".

Reactor refuelling disaster

''K-431'', completed around 1965 as unit ''K-31'', was a Project 675 (Echo II)-class submarine with two pressurized water reactors, each of 70 MW_t capacity and using 20% enriched uranium as fuel. On 10 August 1985, the submarine was being refuelled at the Chazhma Bay naval facility near Vladivostok. The submarine had been refuelled and the reactor tank lid was being replaced. The lid was laid incorrectly and had to be lifted again with the control rods attached. A beam was supposed to prevent the lid from being lifted too far, but this beam was positioned incorrectly, and the lid with control rods was lifted up too far. At 10:55 AM the starboard reactor became prompt critical, resulting in a criticality excursion of about 5·10¹⁸ fissions and a thermal/steam explosion. The explosion expelled the new load of fuel, destroyed the machine enclosures, ruptured the submarine's pressure hull and aft bulkhead, and partially destroyed the fuelling shack, with the shack's roof falling 70 metres away in the water. A fire followed, which was extinguished after 4 hours, after which assessment of the radioactive contamination began. Most of the radioactive debris fell within of the submarine, but a cloud of radioactive gas and particulates blew to the north-west across a stretch of the Dunay Peninsula, missing the town of Shkotovo-22, from the dock. The contaminated forest area was later surveyed as in a swath long and wide. Initial estimates of the radioactive release were about 74  PBq (2  MCi) of noble gases and 185 PBq (5 MCi) of other fission products, but most of this was short-lived isotopes; the estimated release inventory one hour after the accident was about 37 TBq (1000 Ci) of non-noble fission products. In part because the reactor did not contain spent fuel, the fraction of biologically active isotopes was far smaller than in the case of the Chernobyl disaster.

M. Takano ''et al.'' suggest that only 29 GBq of I-131 was released, but larger amounts (620 GBq of I-133 and 1840 GBq of I-135) of other isotopes. The same source suggests that the total release was about 259 PBq but due to radioactive decay this decreased to 43 TBq after 24 hours. The same source suggests that the fission yield was 5·10¹⁸ fissions which would deliver 156  MJ of heat into the reactor.

Ten naval personnel were killed (8 officers and 2 enlisted men), probably by the explosion itself and not from radiation injuries. Radiation injuries were observed in 49 people, with 10 developing radiation sickness; the latter figure included mostly firefighters, some of whom sustained doses up to 220  rad (2.2  Gy) external and 400 rem (4  Sv) to the thyroid gland. Of the 2,000 involved in clean-up operations, 290 were exposed to higher levels of radiation compared to normal standards.

High-level waste gathered during clean-up operations was placed in temporary disposal sites. Due to the rapid decay of most of the fission products and the cleanup operations, some dockyard facilities were able to resume operations four days later. About two months post-accident the radioactivity in water in the cove was comparable to background levels, and 5–7 months post-accident the radiation levels were considered normal throughout the dock area. The damaged submarine was towed to Pavlovsk Bay and berthed there.

References

Bibliography

*
*

External links

Project 675 / Echo IIBellona: Nuclear submarine accidents
(This report incorrectly identifies K-431 as Soviet submarine K-314 when describing the refueling criticality accident.

{{DEFAULTSORT:K-431
Echo-class submarines
Ships built in the Soviet Union
1964 ships
Cold War submarines of the Soviet Union
Maritime incidents in 1985
Soviet submarine accidents
Military nuclear accidents and incidents
1985 in military history
Ships built by Amur Shipbuilding Plant