STS-114

STS-114 was the first "Return to Flight" Space Shuttle mission following the Space Shuttle ''Columbia'' disaster. ''Discovery'' launched at 10:39 EDT (14:39 UTC), July 26, 2005. The launch, 907 days (approx. 29 months) after the loss of ''Columbia'', was approved despite unresolved fuel sensor anomalies in the external tank that had prevented the shuttle from launching on July 13, its originally scheduled date.

The mission ended on August 9, 2005, when ''Discovery'' landed at Edwards Air Force Base in California. Poor weather over the Kennedy Space Center in Florida hampered the shuttle from using its primary landing site.

Analysis of the launch footage showed debris separating from the external tank during ascent; this was of particular concern because it was the issue that had set off the ''Columbia'' disaster. As a result, NASA decided on July 27 to postpone future shuttle flights pending additional modifications to the flight hardware. Shuttle flights resumed a year later with STS-121 on July 4, 2006.

Crew

Original crew

This mission was to carry the Expedition 7 crew to the ISS and bring home the Expedition 6 crew. The original crew was to be:

Mission highlights

STS-114 marked the return to flight of the Space Shuttle after the ''Columbia'' disaster and was the second Shuttle flight with a female commander (Eileen Collins, who also commanded the STS-93 mission). The STS-114 mission was initially to be flown aboard the orbiter '' Atlantis'', but NASA replaced it with ''Discovery'' after improperly installed gear was found in ''Atlantis''' Rudder Speed Brake system. During OMM for ''Discovery'', an actuator on the RSB system was found to be installed incorrectly. This created a fleet wide suspect condition. The Rudder Speed Brake system was removed and refurbished on all three remaining orbiter vehicles, and since ''Discovery'''s RSB was corrected first, it became the new Return to Flight vehicle, superseding ''Atlantis''. Seventeen years prior, ''Discovery'' had flown NASA's previous Return to Flight mission, STS-26.

The STS-114 mission delivered supplies to the International Space Station. However, the major focus of the mission was testing and evaluating new Space Shuttle flight safety techniques, which included new inspection and repair techniques. The crewmembers used the new Orbiter Boom Sensor System (OBSS) – a set of instruments on a 50-foot (15 m) extension attached to the Canadarm. The OBSS instrument package consists of visual imaging equipment and a Laser Dynamic Range Imager (LDRI) to detect problems with the shuttle's Thermal Protection System (TPS). The crew scanned the leading edges of the wings, the nose cap, and the crew compartment for damage, as well as other potential problem areas engineers wished to inspect based on video taken during lift-off.

STS-114 was classified as Logistics Flight 1. The flight carried the ''Raffaello'' Multi-Purpose Logistics Module, built by the Italian Space Agency, as well as the External Stowage Platform-2, which was mounted to the port side of the Quest Airlock. They deployed MISSE 5 to the station's exterior, and replaced one of the ISS's Control Moment Gyroscopes (CMG). The CMG was carried up on the LMC (Lightweight Multi-Purpose Experiment Support Structure Carrier) at the rear of the payload bay, together with the TPS Repair Box.

The crew conducted three spacewalks while at the station. The first demonstrated repair techniques on the Shuttle's Thermal Protection System. During the second, the spacewalkers replaced the failed gyroscope. On the third, they installed the External Stowage Platform and repaired the shuttle, the first time repairs had been carried out during a spacewalk on the exterior of a spacecraft in flight. On August 1, it was announced that protruding gap fillers on the front underside of the shuttle would be inspected and dealt with during the third spacewalk of the mission. The spacewalk was conducted on the morning of August 3. Robinson easily removed the two fillers with his fingers. Later on the same day, NASA officials said that they were looking closely at a thermal blanket located next to the commander's window on the port side of the orbiter. Published reports on August 4, 2005, said that wind tunnel testing had demonstrated that the orbiter was safe to re-enter with the billowed blanket.

On July 30, 2005, NASA announced that STS-114 would be extended for one day, so that ''Discoverys crew could help the ISS crew maintain the station while the shuttle fleet was grounded. The extra day was also used to move more items from the shuttle to the ISS, as uncertainty mounted during the mission as to when a shuttle would next visit the station. The orbiter's arrival also gave the nearly 200-ton space station a free altitude boost of about 4,000 feet (1,220 m). The station loses about 100 feet (30 m) of altitude a day.

The shuttle hatch was closed the night before it undocked from the ISS. After undocking, the shuttle flew around the station to take photos.

Atmospheric reentry and landing was originally planned for August 8, 2005, at Kennedy Space Center, but unsuitable weather postponed the landing until the next day, then moved it to Edwards Air Force Base in California, where ''Discovery'' touched down at 08:11EDT (05:11 am PDT, 12:11 UTC).

Launch sequence anomalies

Around 2.5 seconds after lift-off, a large bird struck near the top of the external fuel tank, and appeared in subsequent video frames to slide down the tank. NASA did not expect this to hurt the mission because it did not hit the orbiter, and because the vehicle was traveling relatively slowly at the time.

A small fragment of thermal tile, estimated to be around 1.5 inches (38 mm) in size, was ejected from an edge tile of the front landing gear door at some point before SRB separation. A small white area appeared on the tile as the piece detached, and the loose shard could be seen in a single frame of the video. It is unknown what object (if any) struck the tile to cause the damage. The damaged tile was inspected further when the images from the umbilical camera were downloaded on day three. Engineers requested that this area be inspected by the OBSS, and flight managers scheduled the operation for July 29, 2005. This represented the only known possible damage to ''Discovery'' that could have posed a risk during re-entry.

At 127.1 seconds after liftoff, and 5.3 seconds after SRB separation
a large piece of debris
separated from the Protuberance Air Load (PAL) ramp, which is part of the external tank. The debris was thought to have measured 36.3 by 11 by 6.7 inches (922 by 279 by 170 mm) – and to weigh about , or half as much as the piece of foam blamed for the loss of ''Columbia''. The debris piece did not strike any part of the ''Discovery'' orbiter. Images of the external tank taken after separation from the orbiter show multiple areas where foam insulation was missing.

Around 20 seconds later, a smaller piece of foam separated from the ET and apparently struck the orbiter's right wing. Based on the mass of the foam, and the velocity at which it would have struck the wing, NASA estimated it only exerted one-tenth the energy required to cause potential damage. Laser scanning and imaging of the wing by the OBSS did not reveal any damage. On July 27, 2005, NASA announced that it was postponing all Shuttle flights until the foam loss problem could be resolved.

As with ''Columbia'', NASA at first believed that workers' improper installation and handling of the external tanks at the Michoud Assembly Facility in Louisiana caused the foam loss on ''Discovery''. NASA Administrator Michael Griffin stated that the earliest the next shuttle could launch is September 22, 2005, but that's only "if next week, the guys have an ''Aha! effect'' on the foam and spot why this big chunk came off." Later in August, it became clear that a September launch date would not be possible, and that the earliest date for the next launch would be in March 2006. However, because Hurricane Katrina hit the Gulf Coast, the next launch was delayed further. With the destruction suffered by Michoud and NASA's Stennis Space Center in Mississippi due to Hurricane Katrina and the subsequent flooding, the launch of the next shuttle mission ( STS-121) was further delayed until July 4, 2006.

In December 2005 x-ray photographs of another tank showed that thermal expansion and contraction during filling, not human error, caused the cracks that resulted in foam loss. NASA official Wayne Hale formally apologized to the Michoud workers who had been blamed for the loss of ''Columbia'' for almost three years.

In-flight repair

On the third EVA of the mission, two areas on the underside of the shuttle where photographic surveying identified protruding gap fillers were dealt with. According to NASA, the gap fillers, which each serve different purposes, are not required for reentry. One filler prevents "chattering" of tiles during ascent, which would occur due to the sonic booms from the noses of the solid rocket boosters and the external fuel tank. The other, in a different location where there is a wider gap between tiles, simply functions to reduce the gap size between tiles, which in turn reduces heat transfer to the shuttle. Even without this filler NASA did not expect the increased heat to cause a problem during reentry (it is present to avoid a level of heating which would only be problematic if experienced many times over a vehicle's design life). Since the gap fillers are not necessary for re-entry, it was acceptable to simply pull them out. An overview of the situation, including procedures for dealing with the protrusions, were sent electronically to the crew and printed aboard the shuttle. The crew were also able to watch uploaded videos of NASA personnel on the ground demonstrating the repair techniques. Both the videos and 12-page procedure document were also made publicly available via NASA's website.

During the third EVA, both fillers were successfully removed with less than a pound of force and without the need to use any tools. Stephen K. Robinson gave a running commentary of his work: "I'm grasping it and I'm pulling it and it's coming out very easily" ... "It looks like this big patient is cured".

If it was not possible to pull the fillers out, then the protruding sections could have been simply cut off. The gap fillers were made of a cloth impregnated with ceramic – they were stiff and could be easily cut with a tool similar to a hacksaw blade. Protruding gap fillers were a problem because they disrupted the normally laminar air flow under the orbiter during reentry, causing turbulence at lower speeds. A turbulent air flow would result in a mixing of hot and cold air, which could have a major effect on the shuttle temperature.

The decision to make the repair balanced the risks of the EVA with the risks of leaving the protruding gap fillers as they were. It is thought that gap filler protrusions of a similar magnitude were present on previous missions, but were not observed in-orbit. Consideration was also given to the risks of elements of the procedure which would involve the ISS arm being used to carry Stephen K. Robinson below the shuttle, possibly the use of a sharp tool which had the potential to damage the EVA suit or shuttle tiles. The possibility of making things worse by attempting a repair was given serious consideration. Cameras on the shuttle arm and on Robinson's helmet were used to monitor the activities under the shuttle.

Protruding gap fillers had been identified as an issue on previous flights, notably STS-28. A post-flight analysis identified that a gap filler was the likely cause of the high temperatures observed during this re-entry. Protruding gap fillers were also seen on STS-73.

A further in-flight repair was considered to remove or clip a damaged thermal blanket located beneath the commander's window on the port side of the orbiter. Wind tunnel testing by NASA determined that the thermal blanket was safe for re-entry, and plans for a fourth spacewalk were cancelled.

Mission timeline

This timeline is a summary. For a more detailed timeline, se
NASA Timeline of Significant Mission Events

July 13

* 11:55 EDT – The countdown clock was restarted after a programmed 3-hour hold.
* 12:01 EDT – To loud applause and cheers, the crew entered the traditional Astrovan to make their way to the pad.
* 12:30 EDT – The crew arrived at Pad 39B and proceeded into the White Room for boarding.
* 13:32 EDT – Problem with LH2 fuel level sensor reported. Launch Director orders launch scrubbed.
* 13:34 EDT – Crew egress began.
* 13:59 EDT – Crew egress completed.

July 14

* 14:00 EDT – Technical meeting of Mission Management Team to discuss troubleshooting efforts following the draining of the External Tank (ET) the previous night.
* 14:45 EDT – Press conference, earliest possible liftoff moved to Sunday, July 17. During this press conference it was confirmed that the preparations of ''Atlantis'' for the next scheduled flight ( STS-121) were not being delayed while troubleshooting the sensor problem on ''Discovery''. This could have impacted the contingency planning for the mission.

July 26

* 08:08 EDT: Crew boarding complete.
* 09:00 EDT: Shuttle hatch closed.
* 09:24 EDT: T −20 minutes and holding.
* 09:34 EDT: T −20 minutes and counting.
* 09:45 EDT: T-9 minutes and holding.
* 10:27 EDT: Launch Control reports go for launch
* 10:30 EDT: T −9 minutes and counting.
* 10:35 EDT: T −4 minutes, APU activation complete.
* 10:39 EDT: Liftoff, shuttle has cleared the tower
* 10:47 EDT: T +8 minutes, main engine shutdown and fuel tank separation as planned.

July 28

* 07:18 EDT: T +01:20:39 Orbiter docked with ISS after performing the first-ever Rendezvous pitch maneuver

July 30

* 05:46 EDT: T +03:19:07 Noguchi and Robinson begin first spacewalk
* 12:36 EDT: T +04:02:57 Spacewalk completed successfully (duration 6 h 50 min)

August 1

* 04:44 EDT: T +05:18:05 Noguchi and Robinson begin second spacewalk to replace CMG
* 11:14 EDT: T +06:00:35 Spacewalk completed successfully (duration 6 h 30 min)

August 3

* 04:48 EDT: T +07:18:09 Noguchi and Robinson begin third spacewalk. Robinson to remove two protruding gap fillers between thermal insulation tiles. Noguchi installs amateur radio satellite PCSat2 along with the MISSE 5 experiment to test solar cells.
* 10:49 EDT: T +08:00:10 Spacewalk completed successfully (duration 6 h 1 min)

August 6

*01:14 EDT: T+10:14:35 Orbiter crew bids farewell to ISS crew. Hatches between orbiter and ISS closed
*03:24 EDT: T+10:16:45 Orbiter undocks from ISS

August 8

*03:20 EDT: T+12:16:41 Mission Control waves off the first of two landing opportunities for Space Shuttle ''Discovery'' due to low clouds over Kennedy Space Center
*05:04 EDT: T+12:18:25 Mission Control waves off the second landing attempt, delaying the landing for another day. Landing is now tentatively scheduled for 05:07 EDT August 9 at Kennedy Space Center. In the event of inclement weather in Florida, NASA will land ''Discovery'' at Edwards Air Force Base in California, or, as a last resort, White Sands, New Mexico.

August 9

*03:12 EDT: T+13:16:33 Mission Control waves off the first landing opportunity for ''Discovery'' due to bad weather.
*05:03 EDT: T+13:18:24 Mission Control waves off the second landing opportunity due to thunderstorms within the "safety zone" around KSC. Shuttle ''Discovery'' will now land at Edwards Air Force Base in California. The previous landing at Edwards Air Force Base was STS-111 on June 19, 2002. The last previous night landing at Edwards was STS-48 on September 18, 1991.
*06:43 EDT: T+13:20:04 Capcom ( Ken Ham), tells ''Discovery'' that "it's time to come home".
*07:06 EDT: T+13:20:27 ''Discovery'' begins its 2-minute, 42-second retrograde deorbit burn over the Western Indian Ocean to the north of Madagascar.
*07:09 EDT: T+13:20:30 Deorbit burn completed as planned, slowing the shuttle by 186 mi/h (/h).
*07:28 EDT: T+13:20:49 APUs are activated to power the shuttle's control surfaces
*07:40 EDT: T+13:21:01 ''Discovery'' begins to feel the effects of the Earth's atmosphere.
*08:08 EDT: T+13:21:29 Commander Eileen Collins takes control of ''Discovery'' for final approach to Runway 22.
*08:11 EDT: T+13:21:32 ''Discovery'' touches down at Edwards Air Force Base. NASA commentator: "and Discovery is home."
*08:12 EDT: T+13:21:33 Eileen Collins reports "Wheel stop."
*10:13 EDT: Crew leaves shuttle.

Wake-up calls

NASA began a tradition of playing music to astronauts during the Gemini program, which was first used to wake up a flight crew during Apollo 15. Each track is specially chosen, often by their families, and usually has a special meaning to an individual member of the crew, or is applicable to their daily activities.

Crew salute to Husband family

On flight day 10, the entire STS-114 crew, and the crew of Expedition 11 gathered to wish Rick Husband's son Matthew a happy birthday. Rick Husband was the commander of ''Columbia'' on STS-107.

Mission hardware

* SSME 1: 2057
* SSME 2: 2054
* SSME 3: 2056
* External Tank: ET-121
*SRB Set: BI-125
*RSRM Set: 92

Contingency planning

Since the loss of ''Columbia'' in STS-107, it had been suggested that on future shuttle missions there would be a planned rescue capability involving having a second shuttle ready to fly at short notice. Even prior to the sensor problem causing the delay in the launch, a rescue option (called STS-300 by NASA) had been planned, which involved the crew of STS-114 remaining docked at the International Space Station until ''Atlantis'' could be launched with a four-person crew to retrieve the astronauts. ''Discovery'' would then be ditched by remote control over the Pacific Ocean, with ''Atlantis'' bringing back both its own crew, as well as that of ''Discovery''.

A further option for rescue would be to use Russian Soyuz spacecraft. Nikolay Sevastyanov, director of the Russian Space Corporation Energia, was reported by ''Pravda'' as saying: "If necessary, we will be able to bring home nine astronauts on board three Soyuz spacecraft in January and February of the next year".Discovery shuttle destroys USA's image of technological predominance – Pravda.Ru
/ref>

See also

* 2005 in spaceflight
* List of human spaceflights
* List of human spaceflights to the ISS
* List of Space Shuttle missions
* Outline of space science

References

External links

NASA's official Return to Flight site







ET redesign and photos of PAL ramps.






Video – Aerial view of Space Shuttle ''Discovery'' launch from WB-57 aircraft
YouTube

Video of the launch of ''Discovery'' from the KSC Press Site
YouTube

Video showing the bird-strike at launch
YouTube

{{Use American English, date=January 2014

Edwards Air Force Base
Space Shuttle missions
Spacecraft launched in 2005
Spacecraft which reentered in 2005
Articles containing video clips
July 2005 events
2005 in Florida
2005 in California
August 2005 events